Vehicle Body Electrical and Lighting Repair Cost Guide
Below are estimated costs for common electrical and lighting repairs based on our shop rate of $125/hour. Please note that prices may vary depending on vehicle make, model, and parts required.
Headlight ReplacementLabor: 0.5-1 hour ($62.50-$125)
Parts: $20-$300 per headlight
Total Estimated Cost: $82.50-$425
Labor: 0.5 hour ($62.50)
Parts: $50-$200 per light
Total Estimated Cost: $112.50-$262.50
Labor: 0.5-1 hour ($62.50-$125)
Parts: $10-$100
Total Estimated Cost: $72.50-$225
Labor: 1.5-2.5 hours ($187.50-$312.50)
Parts: $150-$300
Total Estimated Cost: $337.50-$612.50
Labor: 1-2 hours ($125-$250)
Parts: $100-$250
Total Estimated Cost: $225-$500
Labor: 1-3 hours ($125-$375)
Parts: $200-$600
Total Estimated Cost: $325-$975
Labor: 2-6 hours ($250-$750)
Parts: $100-$1000
Total Estimated Cost: $350-$1,750
Labor: 1-2 hours ($125-$250)
Parts: $50-$200
Total Estimated Cost: $175-$450
Note: These are approximate costs and may vary based on vehicle specifics and the extent of damage. A detailed inspection is required for accurate pricing. Additional costs may apply for diagnostic time and specialty parts.
Vehicle Body Electrical and Lighting Repair Procedures
Headlight Repair
Common Steps:
- Diagnose the specific issue (bulb, wiring, or module failure)
- Access headlight assembly through hood or wheel well
- Disconnect battery to prevent electrical shorts
- Remove necessary components to access faulty parts
- Replace damaged components (bulb, wiring, or entire assembly)
- Test functionality before complete reassembly
- Perform headlight alignment if necessary
Tail Light Repair
Common Steps:
- Access tail light assembly through trunk or rear panel
- Remove cover or trim pieces
- Disconnect wiring harness
- Replace damaged components
- Verify proper connection and seal
- Test functionality
Power Window Repair
Common Steps:
- Remove door panel carefully
- Inspect window regulator and motor
- Test electrical connections
- Replace faulty components (motor, regulator, or switch)
- Lubricate moving parts
- Reassemble door panel
- Test window operation
Central Locking System
Common Steps:
- Diagnose specific door lock actuator or module issue
- Remove door panel
- Access lock mechanism
- Replace faulty actuator or repair wiring
- Program new components if necessary
- Test system functionality
- Reassemble door panel
Dashboard Warning Lights
Common Steps:
- Connect diagnostic scanner
- Read and record error codes
- Identify root cause of warning light
- Repair or replace faulty components
- Clear error codes
- Verify warning light is resolved
- Test drive to ensure problem is fixed
Wiper System Repair
Common Steps:
- Inspect wiper blades and arms
- Check wiper motor function
- Remove cowl or necessary panels
- Replace worn components
- Verify proper wiper arm tension
- Test system in all speeds
- Check washer fluid system operation
Note: These are general repair procedures. Specific steps may vary depending on vehicle make, model, and year. Always consult manufacturer specifications for detailed repair instructions.
Safety Warning:Electrical system repairs should only be performed by qualified technicians. Improper repairs can result in electrical shorts, fire hazards, or system malfunctions.
Vehicle Body Electrical and Lighting Systems
No content available for this section.
Common Failure Symptoms: Vehicle Body Electrical Systems and Lighting Components
Vehicle Body Electrical and Lighting Systems - Signs of Failure & Maintenance Guide
Headlights
Signs of Failure:
- Dim or flickering lights
- One or both headlights not working
- Yellowed or cloudy lens covers
- Moisture inside headlight assembly
Service Schedule:
- Check operation monthly
- Replace bulbs when burned out
- Clean and restore yellowed lenses every 2-3 years
Tail Lights & Brake Lights
Signs of Failure:
- Burned out bulbs
- Cracked lens covers
- Water infiltration
- Intermittent operation
Service Schedule:
- Check operation monthly
- Replace bulbs immediately when burned out (safety requirement)
- Clean contacts annually
Battery
Signs of Failure:
- Slow engine cranking
- Battery warning light illuminated
- Corroded terminals
- Swollen battery case
- Electrical systems functioning poorly
Service Schedule:
- Test battery strength annually
- Clean terminals every 6-12 months
- Replace typically every 3-5 years
Alternator
Signs of Failure:
- Battery warning light on
- Dim or flickering lights
- Dead battery
- Squealing sounds from engine bay
- Electrical accessories working poorly
Service Schedule:
- Test output during regular service intervals
- Replace when failing (typically 7-10 years)
Power Windows
Signs of Failure:
- Slow or jerky operation
- Grinding noises
- Window not moving when switch pressed
- Window falling into door
Service Schedule:
- No regular maintenance required
- Repair/replace components when issues arise
Power Door Locks
Signs of Failure:
- Locks not responding to key fob
- Unusual sounds when operating
- Locks operating intermittently
- Individual doors not locking/unlocking
Service Schedule:
- No regular maintenance required
- Replace actuators when failing
Fuses & Relays
Signs of Failure:
- Specific electrical components not working
- Blown fuses
- Clicking sounds from relay box
- Intermittent electrical issues
Service Schedule:
- Check when electrical issues arise
- Replace fuses and relays as needed
- Keep spare fuses in vehicle
Interior Lights
Signs of Failure:
- Lights not illuminating
- Flickering lights
- Dome light staying on
- Dim lighting
Service Schedule:
- Check operation monthly
- Replace bulbs when burned out
- Clean contacts if flickering occurs
Note: These are general guidelines. Always consult your vehicle's owner's manual for specific maintenance schedules and procedures.
How It Works
- Get a quote online or set-up a time to have your vehicle looked at.
- Pick time slots that work for you, easily, online.
- We will confirm appointments and send reminders.
- Our mechanics bring everything that is needed to you.
- All you have to do is provided a safe area for the work to be performed.
What we need from you
- A safe place to work on your vehicle
- No working on the side of busy roads
- No working on unstable or steep surfaces.
- We do not perform repairs during severe weather.
- Authorization from a property owner or management.
- Repair work done in a parking lot or at your requires permission.
- We do not do repairs in areas restricted by law.
Common Questions
Service Area
Our primary service area is greater Grand Rapids and includes Comstock Park, East Grand Rapids, Grandville, Kentwood, Walker, and Wyoming
Our secondary service area is provided by our Belding location and includes: Belding, Greenville, Ionia and the sorrounding areas.
Contact us if you have any questions about where we provide services.
